Back MILITARY INSPECTOR 801M
General Specifications
Model Number 801M "Military Inspector"
Equipment Use Combat readiness tester for prime movers, combat vehicles and military trailers.
Included Test Systems Electrical (lighting), Air and Air-Brake tests for 12 and 24VDC tractor and trailer systems
Shop Cart Dimensions 20"(W) x 32"(H) x 31"(D)
800A Tester Dimensions 18.5"(W) x 16"(H) x 11"(D)
800A Tester Weight 26 lbs
Total Shipping Weight 130 lbs (assembled with power supply)
Enclosure Durable, powder-coated aluminum (inside and outside)
Mounting Options Both the 800A Tester and the 312 Dual Voltage Power Supply enclosure are pre-mounted to the shop cart
Operating Voltage 800A Tester - 12V or 24V DC; 801M Test System - 110V or 220V AC
Electrical System
Electrical Tests Active fault identification with audible alarms: trailer electrical systems, ABS, 7-way Cable Test
All Circuit Test Monitors all 6 circuits on 7-Way cable: Brake, Marker, Auxiliary, Left, Right and Tail
Direct Fault ID Identifies OPEN, OPEN GROUND, SHORT, and CHASSIS SHORT via 7-way connection
Volt, Amperage Meters Digitally monitors output voltage and amperage in single and multi-circuit modes both on control panel and computer monitor
Tractor Test Identifies "over voltage" and "under voltage" conditions that occur on the tractor's 7-way circuits
Power Supply 12V or 24Volt, filtered and regulated
Air Testing Equipment
Air Tests Remotely control Air Brakes; conduct full Air Leak tests with only the Emergency Air, or both Service and Emergency; with the Brake Pedal Actuator, remotely control tractor and trailer brakes at the same time
Air Supply
Clean, dry air at 110 to 120 psi
Delivered Service Air Internal pressure regulator provides filtered, regulated air at 85-90psi
Delivered Emergency Air 110 psi of clean, filtered and regulator air
Air Pressure Gauges Custom built air gauges with 2 psi increments allow air systms to be inspected for leaks in 60 seconds or less
Compounding Protection Computer will not allow Service Air to be applied before Emergency Air is applied
Air Tank Volume 1488 cubic inches
Pressure Rating 150 psi
Filter Regulator Pres. Rating 150 psi
Filter Regulator Set Pressure 110 psi
Remote Control
Remote Functions Control Emergency and Service air, and each of the six circuits on the 7-way: Brake, Marker, Aux, Left, Right and Tail
Effective Operating Dist. 100'
Power Requirements Operates on 4 AA Batteries (included)
Tester-specific Remote Each remote is keyed to the tester it is shipped with via an internal DIMM switch allowing multiple testers in the same area.